REFLECTOR: Unbalanced fuel flow in flight

[Laurence Coen]

Richard,

I made my permanent fix before my first flight by installing adjustable rudder stops.  The attached fuzzy phone photos should give you an idea of how simple it was.  The screw mount and stop in the rudder root are 3/8" aluminum "U" channel.  The screw is a 8-32 stainless Allen head screwed into a nut plate.  Each turn = one mixing stick.  The "U" channel is pop riveted in place and sitting on a pad of stir stick/micro to transfer load to the rudder root and winglet root. IMHO it beats the heck out of gluing in shims and it took me less than an hour to make and install them.  I was all smiles when it came time to tweak my rudders.

Larry Coen
N136LC


From: Richard J. Gentil 
Sent: Sunday, March 13, 2011 9:37 AM
To: Velocity Aircraft Owners and Builders list 
Subject: Re: REFLECTOR: Unbalanced fuel flow in flight


I was circling over the field and I did change directions in the circle expecting the left tank to burn fuel while it was the high wing. It did not seem to happen. 


Fuel cap is air tight on both sides. Recently verified by pressurizing the system and leaving an airspeed indicator connected for several days. 


The ball is slightly out to the left. I hesitate to do a permanent fix till I get to the gear up and normal cruise test. 





I will conduct the string test next flight.  


Probably use some tongue depressors and five minute to set the yaw till I start flying with the gear up and set it permanently. 


Richard

Sent from my iPhone 4

On Mar 13, 2011, at 9:47 AM, John Abraham <jabraham03 at gmail.com> wrote:


  Richard,

  To add to Jerry and Scott, dont rely on your ball in the aircraft to be correct.  Tape a 6-12" string at the base of the wind screen (outside of aircraft) and you will be able to determine rigging better.  This will account for any panel installation errors.  I have experienced 10 gallons out of one tank before the other has moved.  Try to go for a flight long enough to burn off half a tank.  Be sure you change directions for circling too! That will affect feeding if you always make left turns, it will not let the left side feed as well.

  John


  On Sun, Mar 13, 2011 at 8:27 AM, Richard J. Gentil <richard at naples-air-center.com> wrote:

    Friday I completed my second test flight.  I found that all the fuel drained from the right side and none from the left while on the one hour flight. (I actually cut the flight short due to this.)

    When I landed I verified with my fuel stick that all the fuel did co e from the right tank.

    For troubleshooting:

    1) I removed the line from the left tank to the sump tank and verified that fuel did flow freely from the left tank.

    2) Removed the vent line from the left tank and tested the line in the direction of the left tank and in the direction to the vent/overflow block at the top of my firewall using compressed air.

    3) I checked the check valve for the air for correct operation in both directions and verified it was installed in the correct direction for air to enter and that fuel would not vent into the cabin.

    4) Verified the overflow line was clear by using compressed air.

    I know the picture is hard to follow but this is the fuel system:




    Richard

    Sent from my iPhone 4
    _______________________________________________
    To change your email address, visit http://www.tvbf.org/mailman/listinfo/reflector

    Visit the gallery!  www.tvbf.org/gallery
    user:pw = tvbf:jamaicangoose
    Check new archives: www.tvbf.org/pipermail
    Check old archives: http://www.tvbf.org/archives/velocity/maillist.html




  -- 
  John Abraham
  CFII
  321-543-6243

  _______________________________________________
  To change your email address, visit http://www.tvbf.org/mailman/listinfo/reflector

  Visit the gallery!  www.tvbf.org/gallery
  user:pw = tvbf:jamaicangoose
  Check new archives: www.tvbf.org/pipermail
  Check old archives: http://www.tvbf.org/archives/velocity/maillist.html


--------------------------------------------------------------------------------


_______________________________________________
To change your email address, visit http://www.tvbf.org/mailman/listinfo/reflector

Visit the gallery!  www.tvbf.org/gallery
user:pw = tvbf:jamaicangoose
Check new archives: www.tvbf.org/pipermail
Check old archives: http://www.tvbf.org/archives/velocity/maillist.html
-------------- next part --------------
An HTML attachment was scrubbed...
URL: <http://www.tvbf.org/mailman/private/reflector/attachments/20110314/a7f9af06/attachment-0001.htm>
-------------- next part --------------
A non-text attachment was scrubbed...
Name: Photo03131342.jpg
Type: image/jpeg
Size: 86466 bytes
Desc: not available
URL: <http://www.tvbf.org/mailman/private/reflector/attachments/20110314/a7f9af06/attachment-0002.jpg>
-------------- next part --------------
A non-text attachment was scrubbed...
Name: Photo03131341.jpg
Type: image/jpeg
Size: 100904 bytes
Desc: not available
URL: <http://www.tvbf.org/mailman/private/reflector/attachments/20110314/a7f9af06/attachment-0003.jpg>